Evaluation on Thermo-Electrical Characteristics of Sio2 Nanofluids for Fuel Cell Cooling Application in Automobiles

  • Authors

    • Suleiman Akilu
    • Aklilu Tesfamichael Baheta
    • K V. Sharma
    2018-08-01
    https://doi.org/10.14419/ijet.v7i3.17.16638
  • SiO2, nanofluid, electrical conductivity, thermal conductivity, PEM fuel cell

  • Abstract

    Effective thermal management is critical requirement in fuel cell technologies to avoid the performance degradation during operation. Nanofluids offer the potential to address this cooling challenge in fuel cells better than pure fluids. However, due to the electrochemical changes associated with the proton exchange membrane system, a strict limit on thermal and electrical properties of coolant needs to comply. In this study, the thermal and electrical conductivities of silicon dioxide (SiO2) dispersion of ethylene glycol (EG), glycerol (G), and 40:60 by mass ethylene glycol-glycerol (EG/G) was investigated experimentally. Measurements were carried for particle volume concentrations of 0.25–2.0% at a temperature of 30 °C. The thermal and electrical conductivity of the nanofluids significantly increases with SiO2 loading. Maximum enhancements of ∼4.0% and ∼198% at a volume concentration of 2.0% were obtained with SiO2-EG/G, respectively. Further, analysis of the results reveals that SiO2/G exhibited the greatest thermo-electrical performance, followed by SiO2-EG/G and EG. Therefore, SiO2-EG/G nanofluid is best-suited coolant for PEM fuel cell thermal applications.

     

     

  • References

    1. [1] Talib S., Azmi W., Zakaria I., Mohamed W., Mamat A., Ismail H., 2015, "Thermophysical Properties of Silicon Dioxide (SiO2) in Ethylene Glycol/Water Mixture for Proton Exchange Membrane Fuel Cell Cooling Application," Energy Procedia, vol. 79, pp. 366–371, 2015.

      [2] Choi S. U. S. and Eastman J. A. 1995. Enhancing thermal conductivity of fluids with nanoparticles, in developments and applications of non-Newtonian flows, in: D.A. Singer, H.P. Wang (Eds.), American Society of Mechanical Engineers, New York, FED–231/MD-66, 1995, pp. 99–105.

      [3] Eastman J. A., Choi U. S., Li S., Thompson L. J., and Lee S. 1997. "Enhanced Thermal Conductivity through the Development of Nanofluids," in Proceedings of the Symposium on Nanophase and Nanocomposite Materials IIâ€, USA, pp. 3–11.

      [4] Khdher A. M., Sidik N. A. C, Hamzah W. A. W., and Mamat R. 2016. "An experimental determination of thermal conductivity and electrical conductivity of bio glycol based Al2O3 nanofluids and development of new correlation," International Communications in Heat and Mass Transfer, vol. 73, pp. 75–83.

      [5] R. Angayarkanni S. and Philip J. 2014. "Effect of Nanoparticles Aggregation on Thermal and Electrical Conductivities of Nanofluids," Journal of Nanofluids, vol. 3, pp. 17–25.

      [6] Adio S. A., Sharifpur M., and Meyer J. P. 2015. "Investigation into Effective Viscosity, Electrical Conductivity, and pH of γ-Al2O3-Glycerol Nanofluids in Einstein Concentration Regime," Heat Transfer Engineering, vol. 36, pp. 1241–1251.

      [7] Sharifpur M., Meyer J. P, and Adio S. 2015. "Experimental investigation on the viscosity, electrical conductivity and pH of SiO2-ethylene glycol nanofluids" International Conference on Heat Transfer, Fluid Mechanics and Thermodynamics.

      [8] Żyła G.and Fal, J. 2017. "Viscosity, thermal and electrical conductivity of silicon dioxide–ethylene glycol transparent nanofluids: An experimental study," Thermochimica Acta, vol. 650, pp. 106-113.

      [9] Maxwell J. C. 1881. Treatise on Electricity and Magnetism, second ed. Oxford, UK: Clarendon Press.

      [10] Cruz R. C., Reinshagen J., Oberacker R., Segadães A. M., and Hoffmann M. J. 2005. "Electrical conductivity and stability of concentrated aqueous alumina suspensions," Journal of colloid and interface science, vol. 286, pp. 579–588,

      [11] Dow Chemical Company Inc., Physical properties of ethylene glycols. Available: http://www.dow.com/ethyleneglycol/about/properties.htm.

      [12] Dean J. A. 1985. "Lange's handbook of chemistry,"

      [13] Adio S. A., Sharifpur M., and Meyer J. P. 2015. "Factors affecting the pH and electrical conductivity of MgO–ethylene glycol nanofluids," Bull. Mater. Sci, vol. 38, pp. 1345–1357.

      [14] Zawrah M. F., Khattab R. M., Girgis L. G., El Daidamony H., and Abdel Aziz R. E. 2014. "Stability and electrical conductivity of water-base Al2O3 nanofluids for different applications," HBRC Journal

      [15] Zakaria I., Azmi W. H., Mohamed W. A. N. W., Mamat R., and Najafi G. 2015. "Experimental Investigation of Thermal Conductivity and Electrical Conductivity of Al2O3 Nanofluid in Water - Ethylene Glycol Mixture for Proton Exchange Membrane Fuel Cell Application," International Communications in Heat and Mass Transfer, vol. 61, pp. 61–68.

  • Downloads

  • How to Cite

    Akilu, S., Tesfamichael Baheta, A., & V. Sharma, K. (2018). Evaluation on Thermo-Electrical Characteristics of Sio2 Nanofluids for Fuel Cell Cooling Application in Automobiles. International Journal of Engineering & Technology, 7(3.17), 137-140. https://doi.org/10.14419/ijet.v7i3.17.16638

    Received date: 2018-07-31

    Accepted date: 2018-07-31

    Published date: 2018-08-01