Dynamic and hybrid phase shift controller for dual active bridge converter

  • Authors

    • S. Narasimha Woosong University
    • S. Surender Reddy TKR College of Engineering & Technology
    2019-02-15
    https://doi.org/10.14419/ijet.v7i4.24019
  • Hybrid Phase Shift Control, Extended Phase Shift, Triple Phase Shift, Dual Active Bridge Converter, Buck and Boost Operations.

  • Abstract

    This paper proposes a dynamic dual active bridge (DAB) converter and a hybrid phase shift control (HPSC) scheme for a (0.5-1) variation in the voltage conversion ratio. The proposed HPSC scheme is a combination of extended phase shift (EPS) and triple phase shift (TPS) modulations. It also provides a simple closed-form implementation for the primary and secondary-side phase-shift angles. During the light load operation of dynamic DAB converter, the TPS modulation is employed such that the practical zero voltage sequence operation can be extended to zero load. For heavy loads, the secondary-side phase-shift angle decreases to zero, hence the EPS modulation is applied. In this paper, the MATLAB Simulink software is used with an input voltage range of (200-400)V and then the output voltage wave forms are investigated for both EPS and TPS modulations for different operating modes of buck and boost operations.

     

     

     

  • References

    1. [1] X. Sun, Y. Shen, W. Li, B. Wang, L. Wang, X. Li, Center-tapped transformer based bidirectional dc-dc converter with wide input voltage range, IEEE Energy Conversion Congress and Exposition (ECCE), Montreal, QC, 2015, pp. 5910-5917.

      [2] Available. [Online]. https://www.ieee.li/pdf/viewgraphs/bidirectional_dc_dc_converter_systems.pdf

      [3] S. Zeljkovic, T. Reiter, D. Gerling, Single-stage reconfigurable DC/DC converter for wide input voltage range operation in HEVs, International Power Electronics Conference (IPEC-Hiroshima 2014 - ECCE ASIA), Hiroshima, 2014, pp. 774-781.

      [4] X. Sun, X. Wu, Y. Shen, X. Li, Z. Lu, A Current-Fed Isolated Bidirectional DC–DC Converter, IEEE Transactions on Power Electronics, vol. 32, no. 9, pp. 6882-6895, Sept. 2017. https://doi.org/10.1109/TPEL.2016.2623306.

      [5] N. Leena, B.D. Raj, R. Gunabalan, Computer-based laboratory teaching tools: An overview of LabVIEW and MATLAB, IEEE International Conference on Engineering Education: Innovative Practices and Future Trends (AICERA), Kottayam, 2012, pp. 1-6. https://doi.org/10.1109/AICERA.2012.6306686.

      [6] J. Wu, Y. Li, X. Sun, F. Liu, A New Dual-Bridge Series Resonant DC–DC Converter With Dual Tank, IEEE Transactions on Power Electronics, vol. 33, no. 5, pp. 3884-3897, May 2018. https://doi.org/10.1109/TPEL.2017.2723640.

      [7] C.H. Cheng, P.J. Cheng, M.T. Wu, Fuzzy logic design of self-tuning switching power supply, Expert Systems with Applications, vol. 37, no. 4, pp. 2929-2936, Apr. 2010. https://doi.org/10.1016/j.eswa.2009.09.043.

      [8] D. Sha, G. Xu, High-Frequency Isolated Bidirectional Dual Active Bridge DC–DC Converters with Wide Voltage Gain, CPSS Power Electronics Series, Springer Nature, 2019. https://doi.org/10.1007/978-981-13-0259-6.

      [9] B. Zhao, Q. Song, W. Liu, Y. Sun, Overview of Dual-Active-Bridge Isolated Bidirectional DC–DC Converter for High-Frequency-Link Power-Conversion System, IEEE Transactions on Power Electronics, vol. 29, no. 8, Aug. 2014. https://doi.org/10.1109/TPEL.2013.2289913.

      [10] D.D. Nguyen, T.N. Duc, G. Fujita, An observer-based digital control system for individually management of active and reactive power of dual-active-bridge DC/DC converter, Journal of International Council on Electrical Engineering, vol. 7, no. 1, pp. 234-241, Sept. 2017. https://doi.org/10.1080/22348972.2017.1369925.

      [11] S.I.S. Garcés, D.G. Montoya, C.A. Ramos-Paja, Sliding-Mode Control of a Charger/Discharger DC/DC Converter for DC-Bus Regulation in Renewable Power Systems, Energies, vol. 9, pp. 1-27, 2016.

      [12] S.V. Drakunov, M. Reyhanoglu, B. Singh, Sliding Mode Control of DC-DC Power Converters, IFAC Proceedings Volumes, vol. 42, no. 19, pp. 237-242, 2009.

      [13] H. Wen, W. Xiao, B. Su, Non-active Power Loss Minimization in a Bidirectional Isolated DC–DC Converter for Distributed Power Systems, IEEE Transactions on Industrial Electronics, vol. 61, no. 12, pp. 6822-6831, Dec. 2014. https://doi.org/10.1109/TIE.2014.2316229.

      [14] M.S. Patil, S.P.Patil, D.N. Kyatanavar, Reversible DC Drive using MOSFET Chopper - A Laboratory Model Development for Undergraduate Students, vol. 50, no. 2, pp. 65-72, 2009.

      [15] A. Tong, L. Hang, G. Li, X. Jiang, S. Gao, Modeling and Analysis of a Dual-Active-Bridge-Isolated Bidirectional DC/DC Converter to Minimize RMS Current With Whole Operating Range, IEEE Transactions on Power Electronics, vol. 33, no. 6, pp. 5302-5316, Jun. 2018 https://doi.org/10.1109/TPEL.2017.2692276.

      [16] Y. Shen, X. Sun, W. Li, X. Wu, B. Wang, A Modified Dual Active Bridge Converter With Hybrid Phase-Shift Control for Wide Input Voltage Range, IEEE Transactions on Power Electronics, vol. 31, no. 10, pp. 6884-6900, Oct. 2016.

      [17] W. Xu, N.H.L. Chan, S.W. Or, S.L. Ho, K.W. Chan, A New Control Method for a Bi-Directional Phase-Shift-Controlled DC-DC Converter with an Extended Load Range, Energies, vol. 10, pp. 1-17, 2017. https://doi.org/10.3390/en10101532.

      [18] W. He, L. Jia, D. Li, J. Gao, A Kind of Self-tuning PID Controller and its Application on Marine Motion Control, Sixth International Conference on Intelligent Systems Design and Applications, Jinan, 2006, pp. 188-191. https://doi.org/10.1109/ISDA.2006.253830.

      [19] B. Zhao, Q. Yu, Z. Leng, X. Chen, Switched Z-Source Isolated Bidirectional DC–DC Converter and Its Phase-Shifting Shoot-Through Bivariate Coordinated Control Strategy, IEEE Transactions on Industrial Electronics, vol. 59, no. 12, pp. 4657-4670, Dec. 2012. https://doi.org/10.1109/TIE.2011.2181136.

      [20] P. Gananchchelvi, J. Yu, M.S. Pukish, Current trends in in-vehicle electrical engineering applications, IECON 2012 - 38th Annual Conference on IEEE Industrial Electronics Society, Montreal, QC, 2012, pp. 6268-6273.

      [21] R.T. Naayagi, A.J. Forsyth, R. Shuttleworth, High-Power Bidirectional DC–DC Converter for Aerospace Applications, IEEE Transactions on Power Electronics, vol. 27, no. 11, pp. 4366-4379, Nov. 2012. https://doi.org/10.1109/TPEL.2012.2184771.

      [22] Y. Xie, J. Sun, J.S. Freudenberg, Power Flow Characterization of a Bidirectional Galvanically Isolated High-Power DC/DC Converter Over a Wide Operating Range, IEEE Transactions on Power Electronics, vol. 25, no. 1, pp. 54-66, Jan. 2010. https://doi.org/10.1109/TPEL.2009.2024151.

      [23] Z. Zhang, Z. Zhang, Y. Cao, Z. Wu, Q. Qian, S. Xie, Research on two current-fed isolated bidirectional DC/DC converters for the battery energy storage application, IEEE Southern Power Electronics Conference (SPEC), Puerto Varas, 2017, pp. 1-6.

      [24] Z. Ling, H. Wang, K. Yan, J. Gan, Optimal Isolation Control of Three-Port Active Converters as a Combined Charger for Electric Vehicles, Energies, vol. 9, no. 9, pp. 1-15, 2016. https://doi.org/10.3390/en9090715.

      [25] Z. Guo, K. Sun, Three-Level Bidirectional DC–DC Converter With an Auxiliary Inductor in Adaptive Working Mode for Full-Operation Zero-Voltage Switching, IEEE Transactions on Power Electronics, vol. 33, no. 10, pp. 8537-8552, Oct. 2018. https://doi.org/10.1109/TPEL.2017.2780853.

      [26] M. Yaqoob, K. H. Loo, Y.M. Lai, A Four-Degree-Of-Freedom Modulation Strategy for Dual-Active-Bridge Series-Resonant Converter Designed for Total Loss Minimization, IEEE Transactions on Power Electronics, 2018.

      [27] B. Zhao, Q. Song, W. Liu, Y. Zhao, Transient DC Bias and Current Impact Effects of High-Frequency-Isolated Bidirectional DC-DC Converter in Practice, IEEE Transactions on Power Electronics, vol. 31, no. 4, pp. 3203-3216, April 2016. https://doi.org/10.1109/TPEL.2015.2445831.

      T. Jiang, J. Zhang, X. Wu, K. Sheng, Y. Wang, A Bidirectional LLC Resonant Converter With Automatic Forward and Backward Mode Transition, IEEE Transactions on Power Electronics, vol. 30, no. 2, pp. 757-770, Feb. 2015. https://doi.org/10.1109/TPEL.2014.2307329

  • Downloads

  • How to Cite

    Narasimha, S., & Surender Reddy, S. (2019). Dynamic and hybrid phase shift controller for dual active bridge converter. International Journal of Engineering & Technology, 7(4), 4795-4800. https://doi.org/10.14419/ijet.v7i4.24019

    Received date: 2018-12-15

    Accepted date: 2019-01-13

    Published date: 2019-02-15