Development Prospects of Transportation in the Agroindustrial Complex by Reducing the Damage of Fruit and Vegetable Products When using the Pneumatic Container

  • Authors

    • Byshov N.V
    • Borychev S.N
    • Uspenskiy I.A
    • Shemyakin A.V
    • Yukhin I.A.
    • Fedyashov D.A
    • Piskachev I.A
    2018-12-09
    https://doi.org/10.14419/ijet.v7i4.36.24920
  • Pneumatic container, transportation of fruits and vegetables, damage to fruits and vegetables, container transportation, container.

  • Abstract

    The aim of the study is to reduce damage to potatoes in the body of vehicles when placed in containers for intrafarm transportation due to the development of new science-based technical solutions. Research methods are theoretical studies performed on the basis of laws and methods of theoretical mechanics. The task of the study is to determine the damage of potatoes when conducting laboratory tests on a shaker table that simulates the movement of a vehicle. The shaker table is a control unit, an installation that generates a reciprocating motion and a platform attached to the installation, which produces oscillatory movements of specified parameters. When imitating the movement of a vehicle, the following parameters were set: platform oscillation frequency from 6 Hz to 10 Hz, with increment of 2 Hz; the oscillation speed of the cargo platform from 1.8 m / s to 3.0 m / s, with 0.6 m / s increment and platform oscillation amplitude of 20 mm. Each stage of the experiment lasted for 2 minutes. According to the results of the experiment and the analysis of the damage to potatoes, the values of damage were obtained, which do not go beyond the maximum permissible agrotechnical requirements of 5 %, with the maximum specified vibration parameters. The results of the experiment suggest that the use of a pneumatic container leads to a decrease in the damage of potatoes when the vehicle is moving along a micro-profile of field roads. When using this pneumatic container, the share of damaged products decreases by 0.6-1.1 % with an increase in the vehicle speed by 1.7 times.

     

     

     

  • References

    1. [1] Byshov N.V., Borychev S.N., Kolchin N.N., Uspenskiy I.A. and Yukhin I.A. 'Foreign vehicles for modern agricultural production', Herald of Ryazan State Agrotechnological University Named after P.A. Kostychev, 2012, no. 4 (16), pp. 84-87.

      [2] Uspensky I.A., Yukhin I.A., Kolupaev S.V. and Zhukov K.A. 'Algorithm of preserving the quality of fruits and vegetables during harvesting and transportation', Technique and equipment for the village, 2013, no. 12, pp. 12-15.

      [3] Yukhin I.A. 'Background to the development of universal vehicles for intrafarm transportation of fruits and vegetables', Herald of Ryazan State Agrotechnological University Named after P.A. Kostychev, 2013, no. 4 (20), pp. 88-90.

      [4] Yukhin I.A., Kulik S. and Ryabchikov D.S. 'The loading and unloading device', Rural Mechanic, 2009, no. 10, pp. 30-31.

      [5] Byshov N.V., Borychev S.N., Kashirin D.E., Kokorev G.D., Kostenko M.Yu., Rembalovich G.K., Simdyankin A.A., Uspensky I.A., Shemyakin A.V., Yukhin I.A., Danilov I.K., Ryadnov A.I. and Kosulnikov R.A. ‘Theoretical studies of the damage process of easily damaged products in transport vehicle body during the on-farm transportation’, ARPN Journal of Engineering and Applied Sciences, 2018, vol. 13, no. 10, pp. 3502-3508.

      [6] Bychkov V.V., Uspenskiy I.A. and Yukhin I.A. 'Analysis of studies of the influence of various factors on the safety of vegetables and fruits during intrafarm transportation', Fruit and berry growing in Russia, 2012, vol. 30, pp. 463-469.

      [7] Anisimov B.V., Chugunov V.S. and Shatilova O.N. 'Potato production in the Russian Federation in 2006', Potatoes and Vegetables, 2007, no. 2, pp. 2-3.

      [8] Aldoshin D.N., Aldoshin N.V., Pekhutov A.S. Improving adaptation of vehicles to the transport of agricultural goods // Modern Science Success. 2017. Volume 4. â„– 1. P. 33-35.

      [9] Anikin N.V., Byshov N.V., Uspenskiy I.A., Yukhin I.A. 'Analusis of intrafam transportation of agricultural products', Collection of Articles of the II International Scientific and Production Conference “Perspective Directions for the Development of the Motor Transport Complexâ€, Penza, 2009, pp. 111-113.

      [10] Isaev I.A. Development of an automated system for dimensions and mass control of heavy-duty transportation vehicles // Modern Science Success. 2017. Volume 5. â„– 4. P. 34-38.

      [11] Uspensky I.A., Yukhin I.A. and Zhukov K.A. 'Advanced devices for increasing the safety of fruits and vegetables during intrafarm transportation', Polythematic network electronic scientific journal of Kuban State Agrarian University (Scientific Journal of KubSAU) [Electronic resource], Krasnodar, KubSAU, 2014, no. 01 (095), pp. 1104-1114. – IDA [article ID]: 0951401064. – Mode of access: http://ej.kubagro.ru/2014/01/pdf/64.pdf.

      [12] James P. Yanta and Cindy B. Tong. ‘Commercial Postharvest Handling of Potatoes (Solanum tuberosum)’, Regents of the University of Minnesota, 2013.

      [13] Bridgette Matzinger and Cindy Tong. ‘Commercial Postharvest Handling of Fresh Market Apples (Malus sp.)’, Regents of the University of Minnesota, 2013.

      [14] Tomlins K.I., Ndunguru G.T., Rwiza E. and Westby A. ‘Postharvest handling, transport and quality of sweet potato in Tanzania’, Journal of Horticultural Science and Biotechnology, 2000, 75(5), pp. 586-590.

      [15] Kiran Shetty, Mark Casada, Hua Zhu, Mike Thornton and Philip Nolte ‘Fresh-Pack Potatoes: Handling, Packaging, and Transportation in Refrigerated Railcars’, Idaho Agricultural Experiment Station, 1998, 16 p.

      [16] Lisinska, G. ‘Potato science and technology’, Elsevier science publishers LTD, 1989, 391 p.

      [17] Bolieva Z.A., Dzhioeva Ts.G., Pliev I.G. Ecological conditions and various peculiarities of growing potato // Modern Science Success. 2017. Volume 1. â„– 9. P. 116-120.

      [18] Carl J. Rosen and Roger Eliason ‘Nutrient Management for Commercial Fruit and Vegetable Crops in Minnesota’, Department of Soil, Water, and Climate University of Minnesota, 2005, 40 p.

      [19] Yukhin I.A. 'Reducing damage to potatoes and apples when intrafarm transportation by the vehicle stabilization', dis. ... doctor tech. science, Ryazan, 2017, 388 p.

      [20] Uspenskiy I.A., Yukhin I.A., Kolupaev S.V. and Zhukov K.A. 'Algorithm of preserving the quality of fruits and vegetables during harvesting and transportation', Technique and equipment for the village, 2013, no. 12, pp. 12-15.

      [21] O’Brien M., Claypool L.L., et al. ‘Causes of fruit bruising on transport trucks. – Hilgardia’, 1963, no. 6, vol. 35, pp.113-124.

      [22] O’Brien M., I.P. Gentri, Gibsos R.C., et al. ‚Vibrating characteristics of fruits as related, to in transit injury’, Transactions of the ASAE, 1965, no. 2, vol. 8.

      [23] O'Brien M. and Singh R.P. ‘Minimizing fuel energy use in fruit and vegetable food production and transportation’, "Beyond Energy Crisis: Opportunity and Challenge’, 3 rd Int. Conf. Energy Use Manag., Berlin (West), Oct. 26-30, 1981, Vol. 3, Oxford 1.a., 1981, 1741-1744.

      [24] Uspenskiy I.A., Yukhin I.A., Shemyakin A.V., Latyshenok M.B., Terentyev V.V. and Piskachev I.A. 'Reducing the damage of agricultural products (for example, potatoes) when using a pneumatic container', Herald of Ryazan State Agrotechnological University Named after P.A. Kostychev, 2018, no. 1 (37), pp. 104-108.

      [25] Pustovalov V.S. 'Improvement of the technological process of transporting apples from the garden and the justification of parameters of the vibratory installation for sealing them in containers', diss ... cand. tech. science, Michurinsk, 1984, 90 p.

      [26] Piskachev I.A. 'Improving the safety of agricultural products during transportation', Coll. of scientific works, Young scientist, 2017, no. 11-3 (145), pp. 49-51.

      [27] Shemyakin A.V., Kostenko M.Yu., Terentyev V.V. and Kostenko N.A. 'Forecasting the quality of the potato harvester work', Rural mechanization, 2013, no. 5 (51), pp. 6-7.

      [28] Piskachev I.A., Terentyev V.V. and Shemyakin A.V. 'Transportation of goods in agriculture', Coll. "Innovative development of the modern agro-industrial complex of Russia", Mat. nat. sc.-prac. conf., Ryazan, 2016, pp. 175-178.

      [29] Piskachev I.A., Terentyev V.V. and Shemyakin A.V. 'Problems of evaluating the damage of fruits and vegetables during field trials', Coll. "Trends in the development of the agro-industrial complex with eyes of young scientists", Mat. of sc.-prac. conf. with international participation, March 2, 2018, Ryazan, FSBEI HE RSATU, pp. 96-99.

  • Downloads

  • How to Cite

    N.V, B., S.N, B., I.A, U., A.V, S., I.A., Y., D.A, F., & I.A, P. (2018). Development Prospects of Transportation in the Agroindustrial Complex by Reducing the Damage of Fruit and Vegetable Products When using the Pneumatic Container. International Journal of Engineering & Technology, 7(4.36), 914-919. https://doi.org/10.14419/ijet.v7i4.36.24920

    Received date: 2018-12-28

    Accepted date: 2018-12-28

    Published date: 2018-12-09